全自動混凝土攪拌車是運輸混凝土的專用車輛，也就是我們常常在街上看見的邊走邊轉的攪拌車，混凝土運輸中通過攪拌筒的緩慢旋轉，可有效地防止混土初凝及離析，從而保證混凝土的輸送質量。那么攪拌車有哪些使用攻略，能幫助我們更好地使用和保養呢？

The fully automatic concrete mixer truck is a specialized vehicle for transporting concrete, which is a type of mixer truck that we often see walking and rotating on the street. During concrete transportation, the slow rotation of the mixing drum can effectively prevent the initial setting and segregation of concrete, thereby ensuring the quality of concrete transportation. So what are the usage guidelines for mixing trucks that can help us better use and maintain them?

1、攪拌車液壓傳動系統液壓油的壓力、油量、油質、油溫應達到規定要求，無滲漏現象。

1. The pressure, oil quantity, oil quality, and oil temperature of the hydraulic transmission system of the mixer truck should meet the specified requirements without any leakage.

2、攪拌運輸中，裝載混凝土量不能超過允許裝載質量。

2. During mixing transportation, the amount of concrete loaded cannot exceed the allowable loading mass.

3、攪拌車在露天停放時，裝料前應先將攪拌筒反轉，使筒內的積水和雜物排出。裝料前，好先向筒內加少量水，使進料流暢，防止粘料。

3. When the mixing truck is parked in the open air, the mixing drum should be reversed before loading, so that the accumulated water and debris inside the drum can be discharged. Before loading, add a small amount of water to the cylinder to ensure smooth feeding and prevent sticking.

4、攪拌車行駛中，接長的卸料槽必須翻轉后固定在卸槽上，再轉與車身垂直部位，用銷軸與機架固定，防止由于不固定而引起擺動打傷行人或影響車輛運行。

4. During the operation of the mixer truck, the extended discharge chute must be overturned and fixed on the discharge chute, then turned to a position perpendicular to the vehicle body, and fixed with a pin shaft and frame to prevent swinging and injuring pedestrians or affecting vehicle operation due to lack of fixation.

5、攪拌車通過橋、洞、庫等設施時，應注意通過高度及寬度，以免發生碰撞事故。特別需要注意的是現在的四軸罐車的長度很長，在通過橋洞高度接近極限時，長長的車身是下圓弧路面上的一道弦，能通過的高度會(huì )減低。

5. When the mixing truck passes through facilities such as bridges, tunnels, and warehouses, attention should be paid to the height and width to avoid collision accidents. It is particularly important to note that the length of current four axle tank cars is very long. When the height of passing through bridge openings approaches the limit, the long body is a chord on the lower curved road surface, and the height that can pass through will be reduced.

6、攪拌裝置連續運轉時間不超過8h。

6. The continuous operation time of the mixing device shall not exceed 8 hours.

7、攪拌車運送混凝土的時間不得超過攪拌站規定的時間，以免影響混凝土質量。

7. The time for transporting concrete by the mixer truck shall not exceed the time specified by the mixing station to avoid affecting the quality of concrete.

8、運送混凝土途中，攪拌筒不得停轉、以防混凝土產生初凝乃離析現象。

8. During the transportation of concrete, the mixing drum must not stop rotating to prevent the initial setting or segregation of the concrete.

9、攪拌筒由正轉變?yōu)榉崔D時，必須先將操縱手柄放中間位置，待攪拌筒停轉后，再將操縱手柄放反轉位置。

9. When the mixing drum changes from positive to reverse, the control handle must be placed in the middle position first. After the mixing drum stops rotating, the control handle must be placed in the reverse position.

10、水箱的水量要經常保持裝滿，以防急用。冬季停車時，要將水箱和供水系統的水放干凈。

10. The water tank should always be kept full to prevent emergency use. When parking in winter, the water tank and water supply system should be drained clean.

在保證混凝土質量的同時，攪拌車的駕駛和保養護理也同樣值得重視，那么攪拌車的使用攻略您要多關注，更多事項的了解就來我們網站http://www.apstzs.com做咨詢！

While ensuring the quality of concrete, the safe driving and maintenance of mixer trucks are also worth paying attention to. Therefore, you should pay more attention to the usage guidelines of mixer trucks. For more information, please visit our website http://www.apstzs.com Consulting!